FORD SCORPIO

1985-1994 of release

Repair and car operation



Ford Skorpio
+ 1.1. Car identification
+ 2. Maintenance service
+ 3. Engines
+ 4. Cooling system
+ 5. Fuel system
+ 6. Coupling
+ 7. Transmissions
+ 8. A kardannyj shaft and the back bridge
+ 9. A steering
+ 10. Suspension brackets
+ 11. Brake system
+ 12. Wheels and tyres
+ 13. A body
- 14. An electric equipment
   14.1. A technical characteristics
   14.2. Safety locks and the relay
   14.3. Electronic blocks of management
   14.4. System of the central blocking
   14.5. System of indexes of turns
   14.6. The fuel computer
   14.7. Additional control system
   - 14.8. The generator
      14.8.1. Removal and generator installation
      14.8.2. Dismantling and generator assemblage
      14.8.3. Replacement of brushes of the generator and a pressure regulator
      14.8.4. The basic malfunctions of the generator
      14.8.5. Tension adjustment клинового a belt
   + 14.9. A starter
   + 14.10. A windscreen screen wiper, knot of indexes and a headlight
   14.11. Removal and installation of a combination of devices
   14.12. External and internal illumination
   + 14.13. An other electric equipment
   + 14.14. Electroschemes



14.8.4. The basic malfunctions of the generator
THE GENERAL DATA

At generator check, and also at car operation it is necessary to observe a number of simple rules not to put the generator out of action:

  – Not to suppose work of the generator with the disconnected storage battery;
  – Not to check generator work on "spark" as thus through diodes the considerable current proceeds, and they fail;
  – Not to check diodes pressure more than 12 In or мегомметром;
  – At carrying out of electrowelding works to disconnect all wires from the generator and from the storage battery;
  – To check knots and chains of an electric equipment and to eliminate malfunctions at the idle engine and the disconnected storage battery.

THE REASON
ELIMINATION METHOD
At ignition inclusion the control lamp of gymnastics of the accumulator does not burn
Wire breakage between the generator, the lock of ignition and a control lamp
To check up pressure on a chain, beginning from the generator
The accumulator is discharged
To check up pressure and, if necessary, to charge the accumulator
The bulb has fused
If it proves to be true, to replace a bulb
Generator brushes leaky adjoin to contact rings
To check up length of brushes and freedom of their moving the holder
The winding of excitation of the generator has burnt down
To check up rotor and diodes which at detection of defects are subject to replacement
The control lamp of gymnastics of the accumulator does not die away at increase in turns of the engine
The pressure regulator has failed
To replace with the new
The wire between the generator and a control lamp has contact to weight
To replace a plait of wires or in addition to isolate a wire
The control lamp of gymnastics of the accumulator burns at the switched off ignition
Diode short circuit
To check up diodes and faulty to replace