FORD SCORPIO

1985-1994 of release

Repair and car operation



Ford Skorpio
+ 1.1. Car identification
+ 2. Maintenance service
+ 3. Engines
+ 4. Cooling system
+ 5. Fuel system
+ 6. Coupling
+ 7. Transmissions
+ 8. A kardannyj shaft and the back bridge
+ 9. A steering
+ 10. Suspension brackets
+ 11. Brake system
+ 12. Wheels and tyres
+ 13. A body
- 14. An electric equipment
   14.1. A technical characteristics
   14.2. Safety locks and the relay
   14.3. Electronic blocks of management
   14.4. System of the central blocking
   14.5. System of indexes of turns
   14.6. The fuel computer
   14.7. Additional control system
   - 14.8. The generator
      14.8.1. Removal and generator installation
      14.8.2. Dismantling and generator assemblage
      14.8.3. Replacement of brushes of the generator and a pressure regulator
      14.8.4. The basic malfunctions of the generator
      14.8.5. Tension adjustment клинового a belt
   + 14.9. A starter
   + 14.10. A windscreen screen wiper, knot of indexes and a headlight
   14.11. Removal and installation of a combination of devices
   14.12. External and internal illumination
   + 14.13. An other electric equipment
   + 14.14. Electroschemes



14.8. The generator
THE GENERAL DATA

SECURITY MEASURES AT WORK WITH THE GENERATOR

At work with the generator it is obligatory to disconnect the accumulator.

Before removal of wires from the generator it is necessary to mark them, for repeated installation strictly on the places.

It is forbidden to disconnect the accumulator or the generator at the working engine.

At carrying out of electrowelding works to disconnect the accumulator and the generator.

Check of working capacity of the generator

PERFORMANCE ORDER
1. To check up and, if necessary, to adjust a tension drive a generator belt.
2. To connect the voltmeter to accumulator plugs.
3. Observing of voltmeter indications, to start the engine. In an operating mode of a starter pressure can fall to 9 volt.
4. To increase turns of the engine to 4000 rpm, thus pressure should increase to 13,7–14,6 volt. It specifies in normal work of the generator and a pressure regulator.
5. At turns of the engine to include of 4000 rpm the headlight of headlights or other powerful consumers of the electric power, thus a power failure should make no more than 0,4 volts.
6. In case of considerable deviations of pressure at check the generator is necessary for checking up in a specialised workshop.